Disinfection of water with Watts SmartStream™ UV 2 GPM, A Series UV system is a simple, rapid physical process. When contaminated water is exposed to the Watts SmartStream's™ 254 nanometer UV light, the UV light penetrates the cell walls of microorganisms and disrupts their genetic deoxyribonucleic acid (DNA) material. This quickly inactivates microorganisms by destroying their ability to replicate and infect. This UV system has the ability to inactivate bacteria, cysts, protozoa, parasites, and viruses. Even mold and algae are inactivated by the powerful effects of UV.
This SmartStream™ UV disinfection system is designed to be used as a point of use disinfection device.
This system is an improved version of the Watts UV (WUV) line. Replacement lamps, quartz sleeves, sleeve o-ring, and controllers are all interchangeable between the WUV and the A Series. The new upgrades include a two-piece quartz sleeve nut with grounding screw, a lamp power wire strain relief in the quartz sleeve nut, and a reconfigured inlet and outlet port arrangement.
The Watts SmartStream™ A Series UV Controllers are designed with simplicity in mind. During normal operation, the LED indicator will be illuminated green. If the lamp burns out then an audible alarm will sound and the Green LED Indicator will change from Green to Red. This informs the user that the system requires servicing.
The flow rate of the system must be properly sized. DO NOT exceed the rated flow rate capacity of the system. Flow controllers are available from Watts to ensure system's rated flow is not exceeded.
- Protection Against Microbiological Contamination
- Chemical Free Disinfection of Water
- Environmentally Friendly "Green" Technology
- Virtually Maintenance Free
- Simple Sizing and Installation
- Reactor Chamber constructed of 304 highly polished stainless steel
- Tough and Reliable reactor chamber design
- Flow Rates of up to 2 GPM
- High output and high efficiency 9,000 hour (1 Year) rated lamps
- Audible and visual alarm to indicate lamp failure
- UL Listed Controller
- 3/8" MPT threaded IN and OUT ports
CALIFORNIA PROP 65 WARNING: This product can expose you to chemicals including mercury, which is known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov.
|Chamber Materials||304 Stainless Steel|
|UV Dose (End of Life)||30 mj/cm2|
|Lamp Life||9,000 Hours|
|Lamps per Chamber||Single|
The quality of the water to be treated must meet the Feed Water Specifications section below. A prefilter with a 5 micron minimum particle size reduction must be installed on the inlet line to the system. Failure to ensure proper pretreatment will result in inadequate disinfection. Watts SmartStream™ UV systems are engineered with the highest quality components. If at anytime a component needs to be replaced, use only parts recommended and supplied by Watts. DO NOT add components to or remove components from this system.
Feed Water Requirements:
|Max Water Pressure:||100 psi (6.9 bar)|
|pH:||6.5 - 8.5|
|Temperature:||36° F to 104° F (2°C to 40°C)|
|Turbidity:||<5 Nephelometric Turbidity Units (NTU)|
|Iron (maximum):||0.3 ppm|
|Manganese (maximum):||0.05 ppm|
|Temperature 122° F / 50° C
90% Relative Humidity
|Oil & H2S:||None Allowed|
Reduction Claims Validated for this unit by WQA (Water Quality Association)
- Model # WA002ABAX. Item # T7400000
- MFG Brand Watts
- Certified to NSF/ANSI 372 Lead-Free
- Certified by WQA
- Watts SmartStream™ UV 2 GPM A Series UV Reactor Chamber
- 120 VAC 60 Hz Electric Ballast
- A 2 GPM UV Lamp
- Two (2) Mounting Clips with Screws
- 3.83" W x 17.65" H x 3.09" D
Position the system in a suitable location. Make sure there is enough clearance between the end of the UV chamber and any obstructions, to allow for the removal of the lamp and quartz sleeve. The SmartStream™ UV disinfection systems should be installed as close as possible to the treated water's point of use.
Watts Regulator Co. (the “Company”) warrants its SmartStream™ ultraviolet disinfection product to be free from defects in material and workmanship under normal usage for the following periods beginning on the date of original shipment:
|Stainless Steel Reactor Chamber||10 Years|
|Flow Switch||3 Years|
|Electronics and Ballast||5 Years Prorated|
|UV Lamp, Quartz Sleeve, UV Sensor,
and all other components
In the event of such defects within the applicable warranty period, the Company will, at its option, repair or replace the product without charge. Defective components are subject to inspection by the Company before any warranty remedy is provided. The Company will cover the cost of shipping any repaired or replaced product to you in the event the original product was found by the Company to be defective. The Company reserves the right to make changes or substitutions in defective parts or components with material of equal quality or value.
A return authorization number, issued by the Company, is required before returning any product to the Company for warranty claim evaluation. You must provide the product model number, serial number, and invoice number when making a warranty claim within the applicable warranty period. The original serial number and model number labeling must be intact on any product at the time any warranty claim is made in order for it to be eligible for a warranty remedy. You are responsible for the cost of shipping any defective product to the Company for inspection. Damage caused by improper handling while the product is in transit is not covered by this limited warranty. This limited warranty is provided by the Company to the original purchaser and is non-transferable.
The SmartStream™ product must be installed in applications with water quality adhering to the Feed Water Quality Guidelines set forth in the Company’s most recently published installation and operation manual or other published product specification sheet. The product must be installed and operated in compliance with the Company’s published installation and operation manual, product specification sheet, and local plumbing codes. This product must be installed in connection with an approved water supply. This product must be operated at water pressures and temperatures that do not exceed the Company’s published specifications. This product is limited to use within atmospheric environments indoors that are within ambient temperature limitations, free from external water contact, where relative humidity is below 95% non-condensing, and that are noncorrosive to the product’s materials of construction, including its electronic components.
The use of any unauthorized or inappropriate replacement parts will void this limited warranty.
THE WARRANTY SET FORTH HEREIN IS GIVEN EXPRESSLY AND IS THE ONLY WARRANTY GIVEN BY THE COMPANY WITH RESPECT TO THE PRODUCT. THE COMPANY MAKES NO OTHER WARRANTIES, EXPRESS OR IMPLIED. THE COMPANY HEREBY SPECIFICALLY DISCLAIMS ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE.
The remedy described above in this Limited Warranty shall constitute the sole and exclusive remedy for breach of warranty, and the Company shall not be responsible for any incidental, special or consequential damages, including without limitation, lost profits or the cost of repairing or replacing other property which is damaged if this product does not work properly, other costs resulting from labor charges, delays, vandalism, negligence, fouling caused by foreign material, damage from adverse water conditions, chemical, or any other circumstances over which the Company has no control. This warranty shall be invalidated by any abuse, misuse, misapplication, improper installation or improper maintenance or alteration of the product.
Some States do not allow limitations on how long an implied warranty lasts, and some States do not allow the exclusion or limitation of incidental or consequential damages. Therefore the above limitations may not apply to you. This Limited Warranty gives you specific legal rights, and you may have other rights that vary from State to State. You should consult applicable state laws to determine your rights. SO FAR AS IS CONSISTENT WITH APPLICABLE STATE LAW, ANY IMPLIED WARRANTIES THAT MAY NOT BE DISCLAIMED, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED IN DURATION TO ONE YEAR FROM THE DATE OF ORIGINAL SHIPMENT.